Research on technology of complex processing of phosphogypsum

User Rating:  / 0
PoorBest 

Authors:

O. V. Nazarenko, orcid.org/0000-0001-5908-9589, Dniprovsk State Technical University, Kamianske, Ukraine, e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.

A. V. Ivanchenko, orcid.org/0000-0002-1404-7278, Dniprovsk State Technical University, Kamianske, Ukraine, e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.

повний текст / full article

 

Naukovyi Visnyk Natsionalnoho Hirnychoho Universytetu. 2020, (5): 109-114

https://doi.org/10.33271/nvngu/2020-5/109

Abstract:

Purpose. To conduct systematic studies on the process of obtaining rare earth elements from phosphogypsum by sulfate acid treatment. To determine the concentration of acid and rare earth elements in the filtrate after phosphogypsum excretion in the samples, depending on the ratio of phosphogypsum : acid 1 : 1.5; 1 : 2 and 1 : 2.5. To test purified calcium sulfate as a reagent for the extraction of phosphates from urban liquid waste sludge, to extract organ–mineral fertilizer from purified phosphogypsum and activated sludge from wastewater treatment plants.

Methodology. For research, a laboratory unit for complex processing of phosphogypsum was prepared and the principle of its work was described. The experimental studies were performed using trilon B titration techniques to determine the rare earth element concentration and NaOH titration to determine the acid concentration. A photometric method was used to determine the concentration of inorganic phosphates in the wastewater.

Findings. The content of acid in the filtrate at different ratio of “phosphogypsum: acid” from the enterprise “Dnipro Mineral Fertilizer Plant” and from the waste heaps was revealed. It is established that the concentration of acid increases with the ratio of “phosphogypsum: acid” from 1 : 1.5 to 1 : 2.5, respectively. The obtained organic-mineral fertilizer corresponds to DSTU 7369:2013.

Originality. The regularities of the process of acid treatment of phosphogypsum depending on the origin have been established, and it is found that the concentration of the rare earth elements and acid is higher in phosphogypsum, which is obtained at the Dnipro Plant of Mineral Fertilizers than in phosphogypsum selected from waste heaps. The dependence of the ratio “phosphogypsum: acid”, namely 1 : 1.5; 1 : 2 and 1 : 2.5 on the concentration of acid and rare earth elements in the samples was found. It was established that the presence of activated sludge in anoxic mode for 30 h leads to an increase in the content of phosphates in the aqueous phase by 2.6–2.8 times. Dependences of the process of extraction of phosphates from urban liquid waste sludge by phosphogypsum were obtained. Organic-mineral fertilizer from activated sludge of urban wastewater treatment plants and purified phosphogypsum was obtained, which meets the requirements of DSTU 7369:2013.

Practical value. A laboratory unit has been developed for obtaining purified phosphogypsum from soluble impurities. It is proposed to use purified phosphogypsum as a raw material in agriculture for the organic-mineral fertilizers and composts production, a reagent for the extraction of phosphates from wastewater and in the building materials industry to obtain gypsum binders. The studies made it possible to quantify the concentration of rare earth elements and acids in phosphogypsum, as well as their possible selection as valuable products from the filtrate.

References.

1. Vinnichenko, V. I., & Supryaga, N. M. (2015). Modern energy-saving technology of processing phosphogypsum into construction products. Materials of international scientific and technical conference. Ternopil.

2. Yavorsky, V. T., Zozulya, H. I., Venchak, Y. V., & Buklov, R. L. (2014). Obtaining gypsum binder from phosphogypsum by direct electric heating. Materials of III international scientific and technical conference. Ternopil. Retrieved from http://elartu.tntu.edu.ua/bitstream/123456789/8514/2/Conf_2014_Yavorsky_V_TObtaining_of_gypsum_binder_69.pdf.

3. Ivashchenko, T. H., Bondar, O. I., Novoselskaya, L. P., & Vinnychenko, V. I. (2017). Phosphogypsum (environmentally friendly ways of disposal and use): monograph. Kherson.

4. Tabachenko, I. O. (2019). Raw materials for the production of phosphate fertilizers. Materials of scientific and technical conference. Sumy.

5. Derevyanko, V. N., Kondratieva, N. V., Hrishko, A. N., & Moroz, L. V. (2019). Phosphogypsum binder. Bulletin of the Pridneprovsk State Academy of Civil Engineering and Architecture, (2), 251-252.

6. Malanchuk, Z. R., Vasylchuk, O. Yu., & Oksenyuk, R. R. (2016). Modern directions of use and processing of technogenic phosphogypsum deposits. Bulletin of NUPPP: Collection of scientific works, (2), 133-139.

7. Khryapina, O. V., & Budyonyi, O. P. (2015). The use of phosphogypsum in the sectors of the economy. Part 2, Materials of scientific and practical conference. Sumy, (pp. 186-187).

8. Tolstov, A. V., Pokhilenko, N. P., & Samsonov, N. Yu. (2017). New opportunities for rare earth elements from a single Arctic source of raw materials. SFU Journal, 10(1), 125-138.

9. Boblyakh, S. P., & Ignatyuk, R. M. (2013). Production of rare-earth metals from secondary raw materials. Dnipro: NSU, (1). 68-73.

10. Petrochenkov, V. H., Bilokin, E. M., & Dulnev, P. H. (2014). Ukraine. Patent No. 92756. Ukraine.

11. Astrelin, I. M., Molyuga, A. I., & Krymets, H. V. (2015). Ukraine. Patent No. 101428. Ukraine.

12. Dvorkin, L. Yu., Marchuk, V. V., & Zhitkovsky, V. V. (2015). Ukraine. Patent No. 102561. Ukraine.

13. Nazarenko, O. V., & Ivanchenko, A. V. (2019). Investigation of the process of acid processing of phosphogypsum. Materials international. Research and Practice Conference. Sofia, Bulgaria, (pp. 328-331).

14. Ischuk, O. O., Dvorkin, L. Yu., Sharabura, I. A., & Skrypnyk, I. H. (2012). Ukraine. Patent No. 69211. Ukraine.

15. Molyuga, A. I., Fedorov, O. S., Astrelin, I. M., & Krymets, H. V. (2014). Ukraine. Patent No. 93253. Ukraine.

16. Voloshin, M. D., Shestozub, A. B., Vlasian, S. V., & Mukhachev, A. P. (2014). Ukraine. Patent No. 88658. Ukraine.

Visitors

6231492
Today
This Month
All days
5324
58169
6231492

Guest Book

If you have questions, comments or suggestions, you can write them in our "Guest Book"

Registration data

ISSN (print) 2071-2227,
ISSN (online) 2223-2362.
Journal was registered by Ministry of Justice of Ukraine.
Registration number КВ No.17742-6592PR dated April 27, 2011.

Contacts

D.Yavornytskyi ave.,19, pavilion 3, room 24-а, Dnipro, 49005
Tel.: +38 (056) 746 32 79.
e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
You are here: Home About the journal EngCat Archive 2020 Contens №5 2020 Research on technology of complex processing of phosphogypsum