Features of structure formation of electrodeposited alloys Fe-Ni Results of the studies of the impact interaction of lumpy rock mass with lining effective surface of machines

User Rating:  / 0
PoorBest 

Authors:

Ye.V. Kolesnik, Cand. Sci. (Tech.), Associate Professor, State Higher Educational Establishment “Ukrainian State University of Chemical Technology”, Senior Lecturer of the Department of Materials Science, Dnepropetrovsk, Ukraine.

Abstract:

Purpose. To determine the features of structure formation of electrodeposited alloys Fe-Ni depending on the concentration of nickel ions in the sulphate electrolyte.

Methodology. Electrodeposited 50 mm thick coatings by Fe-Ni alloys were applied onto low-carbon steel at the temperature 55–57°C and cathode current density 10 A/dm2 from the sulphate electrolyte with the concentration of iron (II) ions – 80 g/l, nickel (II) ions – 1–20 g/l, pH 2–3. X-ray phase analysis of 50 mm thick coatings by Fe-Ni alloys, electrodeposited from sulphate electrolyte, was performed at DRON-3 modernized diffractometer in copper radiation without separation of coatings from the substrate. Crystallographic texture of the samples was estimated by diffractograms, texture curves and invert pole figures. Microstructure of surface was investigated by the method of scanning by electron microscope REM-106I in the mode of secondary electrons.

Findings. It is shown, that the insertion of nickel ions into sulphate iron-plating electrolyte causes the formation of solid solutions based on a-Fe lattice in the electrodeposited coatings, that are characterized by the axial texture <111>, the fraction and the perfection of which increases with the growth of the concentration of nickel in the electrolyte. By the example of iron-nickel coatings the possibility of the formation of spherulites in electrodeposited alloys has been shown. We have found that the formation of the axial texture <111> in electrodeposited Fe-Ni alloys is accompanied by the appearance of spherulites in their structure.

Originality. The influence of the concentration of nickel ions in the electrolyte on structure formation of electrodeposited Fe-Ni alloys has been discovered, the spherulites have been found in their structure. The interdependence between the form of growth of crystals and characteristics of crystallographic texture of the alloys has been found.

Practical value. The obtained results show the possibility of the purposeful formation of certain crystallographic texture in electrodeposited Fe-Ni alloys, which can be used for restoration of the dimensions of depreciated machine components in the mining, metal-working industries and in machine-building. 

References:

 

1. Электролитическое осаждение железа / [Петров Ю.Н., Гурьянов Г.В., Бобанова Ж.И. и др. ] – Кишинев: Штиинца, 1990. – 195 с.

Petrov, Yu.N., Guryanov, G.V. and Bobanova, Zh.I. (1990), Elektroliticheskoye osazhdeniye zheleza [Electrolytic Deposition of Iron], Shtiintsa, Chisinau, Moldova.

 

2. Лихачев В.А. Восстановление изношенных деталей методом холодного железнения / В.А. Лихачев // Гальванотехника и обработка поверхности. – 2006. – № 1. – С. 14–18.

Likhachev, V.A. (2006), “Restoration of depreciated components by the method of cold iron-plating”, Galvanotekhnika i obrabotka poverkhnosti, no. 1, pp. 14–18.

 

3. Ковенский И.М. Металловедение покрытий /  И.М. Ковенский, В.В. Поветкин – М.: Интермет инжиниринг, 1999. – 296 с.

Kovenskiy, I.M. and Povetkin, V.V. (1999), Metallovedeniye pokrytiy [Materials Science of Coatings], Intermet Engineering, Moscow, Russia.

 

4. Czerwinski F. and Szpunar J.A. (1999), “Texture in metallic and ceramic films and coatings”, Textures and Microstructures, no. 1–4, pp. 107–118.

 

5. Колесник Е.В. Изменение совершенства кристаллографической текстуры по толщине электроосажденных железных покрытий / Е.В. Колесник // Металлофизика и новейшие технологии. – 2011. – Спецвыпуск. – С. 401–406.

Kolesnyk, Ye.V. (2011), “Change of perfection of crystallographic texture along the thickness of electrodeposited iron coatings”, Metaloznavstvo ta termichna obrobka metaliv, special issue, pp. 401–406.

 

6. Воленко А.П. Физические основы формирования кристаллов с дисклинационными дефектами и пентагональной симметрией в процессе электрокристаллизации меди: автореф. дисс. на соискан. учен. степени докт. физ.-мат. наук: спец. 01.04.07 / Воленко А.П. // Самарск. гос. техн. ун-т. – Самара, 2004. – 38 с.

Volenko, A.P. (2004), “Physical basis of the formation of crystals with disclination defects and pentagonal symmetry during the process of copper electrocrystallization”, Abstract of Dr. Sci. (Phys.-Math.) dissertation, Samara State Technical University, Samara, Russia.

 

7. Крестниковская Е.А. Образование сферолитов при электроосаждении железа: тезисы докладов II Международн. научн-техн. конф. „Современные методы в теоретической и экспериментальной электрохимии. / Крестниковская Е.А., Неверов И.В. – Плес, Ивановск. обл., Россия. – 2010. – С. 167.

Krestnikovskaya Ye.A. and Neverov, I.V. (2010), “Spherulites formation during iron electrodeposition”, Proc. of the the 2nd Int. Conf. “Modern methods in theoretical and experimental electrochemistry”, Ples, Ivanovo region, Russia, p. 167.

 

 

Files:
2013_5_kolesnik
Date 2014-07-24 Filesize 205.91 KB Download 711

Visitors

6239591
Today
This Month
All days
4045
66268
6239591

Guest Book

If you have questions, comments or suggestions, you can write them in our "Guest Book"

Registration data

ISSN (print) 2071-2227,
ISSN (online) 2223-2362.
Journal was registered by Ministry of Justice of Ukraine.
Registration number КВ No.17742-6592PR dated April 27, 2011.

Contacts

D.Yavornytskyi ave.,19, pavilion 3, room 24-а, Dnipro, 49005
Tel.: +38 (056) 746 32 79.
e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
You are here: Home Archive by field of science Mining mechanics Features of structure formation of electrodeposited alloys Fe-Ni Results of the studies of the impact interaction of lumpy rock mass with lining effective surface of machines