Optimization of general losses of the energy of the frequency-regulated pumping aggregate for start-braking regimes

User Rating:  / 0
PoorBest 

Authors:

V.O.Volkov, Cand. Sc. (Tech.), Assoc. Prof., orcid.org/0000-0003-1262-3988, Dnipro University of Technology, Dnipro, Ukrainе, e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.

Abstract:

Purpose. Analytical calculation and optimization of the total energy losses for a frequency-regulated centrifugal pumping aggregate during start-braking regimes.

Methodology. Variational calculi, mathematical interpolation and computer simulation were used.

Findings. Analytical dependencies are obtained that allow calculating and optimizing the total energy losses of the frequency-regulated centrifugal pump set in the start-braking regimes. The quasi-optimal form of tachograms and the optimal values ​​of the acceleration and deceleration time of this aggregate are defined, at which the minimization of its total energy losses in the start-braking regimes is ensured. Solutions for calculating energy consumption, as well as hydraulic, electromechanical and energy processes for the centrifugal pumping aggregate are implemented.

Originality. For the first time, analytical dependencies were obtained for calculating the total energy losses of a frequency-regulated pump aggregate in the start-braking regimes. A “U”-shape type of the dependences of the total energy losses of a given aggregate on the duration of its acceleration and deceleration time for different velocity trajectories is established. A quasi-optimal trajectory of velocity variation is proposed in the form of a temporal function of the hyperbolic sine with a variable value of the coefficient in its argument, at which the total losses of the pump aggregate in the start-braking regimes are minimal. A comparison is made of the total energy losses of the pump set for a quasi-optimal velocity trajectory with known other trajectories for different duration time of the start-braking regimes, which made it possible to estimate the energy saving achieved thereby.

Practical value. Introduction of the obtained results allows reducing to the minimum possible values the unproductive energy losses for the centrifugal pump aggregate in the start-braking regimes.

References.

1. Yang, H., Shi, Y., Lau, J., & Zhang, T. (2014). An optimal control strategy based on virtual flow measuring for variable flow primary pumping. HVAC&R Research. Winnipeg, Canada,20, 411-423.

2. Ankur, P. D., Rakesh, J. M., & Ajitsinh, R. C. (2014). Energy Conservation Using Variable Frequency Drive in Pumping Application. RTEECE, 121-126.

3. Radam, A. C., Vatavu, S., & Florea, C. (2017). Research regarding the operation of water pumping hydraulic systems. Universitas Publiching Hause. Petrosanim Romania, 2, 25-32.

4. Wang, G., Zheng, X., & Kiamehr, K. (2017). Sequencing Control of Parallel Pumps in Variable-Flow Systems Using Wire-to-Water Efficiency. ASHRAE Transactions, 123, 291-301.

5. Viholainen, J. (2014). Energy-efficient control strategies for variable speed driven parallel pumping systems based on pump operation point monitoring with frequency converters. Lappeenranta,Finland.

6. Os’kin, S. V., Didych, V. A., & Vozmilov, A. G. (2017). Key ways of energy saving in pump units for melioration and irrigation systems. 2017 ICIEAM IEEE. St. Petersburg, Russian Federation, 212-216.

7. Bibik, O. V., Popovich, O. M., & Shevchuk, S. P. (2016). Energy-efficient regimes of the electromechanical system of a pumping unit for many superficial buildings. Technichna electodinamika, 5, 38-45.

8. Volkov, V. A. (2018). Energy-saving control in start-braking regimes of a variable frequency asynchronous engine loaded with a centrifugal pump.Electromehanichni I energozberigauchi sistemi,1(41), 23-36.

9. Volkov, V. О. (2019). Optimization of times of start-braking regimes of frequency-regulated asynchronous engine with pumping load. Naukovyi Visnyk Natsionalnoho Hirnychoho Universytetu, 1(169), 90-98. DOI: 10.29202/nvngu/2019-1/11.

10. Leonov, B. S. (2013). Variable Frequency Electric Pumping Units.

 повний текст / full article



Visitors

6227314
Today
This Month
All days
1146
53991
6227314

Guest Book

If you have questions, comments or suggestions, you can write them in our "Guest Book"

Registration data

ISSN (print) 2071-2227,
ISSN (online) 2223-2362.
Journal was registered by Ministry of Justice of Ukraine.
Registration number КВ No.17742-6592PR dated April 27, 2011.

Contacts

D.Yavornytskyi ave.,19, pavilion 3, room 24-а, Dnipro, 49005
Tel.: +38 (056) 746 32 79.
e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
You are here: Home About the journal editorial board EngCat Archive 2019 Contens №3 2019 Electrical ­Complexes and ­Systems Optimization of general losses of the energy of the frequency-regulated pumping aggregate for start-braking regimes