Recovery of iron and phosphorus removal from Gara Djebilet iron ore (Algeria)

User Rating:  / 0
PoorBest 

Authors:


F.A.Mansour, orcid.org/0000-0002-6694-2725, Laboratoire de Gnie Minier, Dpartement Gnie Minier, Ecole Nationale Polytechnique, El Harrach Algiers, Algeria e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.

M.Ould-Hamou, orcid.org/0000-0002-8770-5323, Laboratoire de Gnie Minier, Dpartement Gnie Minier, Ecole Nationale Polytechnique, El Harrach Algiers, Algeria e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.

A.Merchichi, orcid.org/0000-0001-8136-601X, Laboratoire de Gnie Minier, Dpartement Gnie Minier, Ecole Nationale Polytechnique, El Harrach Algiers, Algeria e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.

O.Gven, orcid.org/0000-0002-5267-9153, Department of Mining Engineering, Faculty of Engineering, Adana Alparslan Trke Science and Technology University, Saram Adana, Turkey, e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.


повний текст / full article



Naukovyi Visnyk Natsionalnoho Hirnychoho Universytetu. 2021, (4): 082 - 088

https://doi.org/10.33271/nvngu/2021-4/082



Abstract:



Purpose.
This research aims to promote the assay of iron and reduce the phosphorus grade of the final DRI.


Methodology.
A high-phosphorus oolitic iron ore from Gara Djebilet deposit underwent the procedure of coal-based direct reduction (coal-based DR) followed by wet low-intensity magnetic separation (WLIMS). The effects of temperature, periods of time and Na2SO4 dosage on phosphorus removal, metallisation degree and iron recovery rate were tried and optimised. Furthermore, phase changes in iron oxides and the distributing features of phosphorus in both reduced and magnetic materials were investigated as well.


Findings.
The appropriate addition of sodium sulfate improves the Fe-P separation during the coal-based DR of Gara Djebilet mixed pellets.


Originality.
Using additives of CaO and sodium sulfate during the coal-based DR-magnetic separation of mixed pellets sourced from Gara Djebilet deposit.


Practical value. The results reveal that a final direct reduced powder (DRI) assaying 96 wt% Fe and 0.16 wt% P at a recovery rate of 97.72% was obtained when the ore-coal-CaO mixed pellets were reduced in the presence of 5 wt% Na
2SO4 at 1250 C for 30 min. Thus, the coal-based DR could be used as an alternative to the blast furnace (BF) route in the steelmaking industry from refractory iron ores.



Keywords:
Gara Djebilet, high-phosphorus oolitic iron ore, coal-based direct reduction, sodium sulfate, magnetic separation

References.


1. Luo, L., & Zhang, H. (2017). Process mineralogy and characteristic associations of iron and phosphorus-based minerals on oolitic hematite. Journal of Central South University, 24(9), 1959-1967. https://doi.org/10.1007/s11771-017-3604-8.

2. Sun, Y., Han, Y., Gao, P., & Yu, J. (2015). Size distribution behavior of metallic iron particles in coal-based reduction products of an oolitic iron ore. Mineral Processing and Extractive Metallurgy Review, 36(4), 249-257. https://doi.org/10.1080/08827508.2014.955611.

3. Yang, M., Zhu, Q.S., Fan, C.L., Xie, Z.H., & Li, H.Z. (2015). Roasting-induced phase change and its influence on phosphorus removal through acid leaching for high-phosphorus iron ore. International Journal of Minerals, Metallurgy and Materials, 22(4), 346-352. https://doi.org/10.1007/s12613-015-1079-x.4. Quast, K. (2018). A review on the characterisation and processing of oolitic iron ores. Minerals Engineering, 126, 89-100. https://doi.org/10.1016/j.mineng.2018.06.018.

5. Hamadeh, H., Mirgaux, O., & Patisson, F. (2018). Detailed modeling of the direct reduction of iron ore in a shaft furnace. Materials, 11(10), 1865-1871. https://doi.org/10.3390/ma11101865.

6. Zhu, D., Guo, Z., Pan, J., & Zhang, F. (2016). Synchronous upgrading iron and phosphorus removal from high phosphorus oolitic hematite ore by high temperature flash reduction. Metals, 6(6), 1-17. https://doi.org/10.3390/met6060123.

7. Rao, M., Ouyang, C., Li, G., Zhang, S., Zhang, Y., & Jiang, T. (2015). Behavior of phosphorus during the carbothermic reduction of phosphorus-rich oolitic hematite ore in the presence of Na2SO4. International Journal of Mineral Processing, 143, 72-79. https://doi.org/10.1016/j.minpro.2015.09.002.

8. Yu, W., Sun, T., Cui, Q., Xu, C., & Kou, J. (2015). Effect of coal type on the reduction and magnetic separation of a high-phosphorus oolitic hematite ore. ISIJ International, 55(3), 536-543. https://doi.org/10.2355/isijinternational.55.536.

9. Cheng, C., Xue, Q., Wang, G., Zhang, Y., & Wang, J. (2016). Phosphorus migration during direct reduction of coal composite high-phosphorus iron ore pellets. Metallurgical and Materials Transactions B, 47(1), 154-163. https://doi.org/10.1007/s11663-015-0479-7.

10. Cheng, C., Xue, Q., Zhang, Y., Han, F., & Wang, J. (2015). Dynamic migration process and mechanism of phosphorus permeating into metallic iron with carburizing in coal-based direct reduction. ISIJ International, 55(12), 2576-2581. https://doi.org/10.2355/isijinternational.ISIJINT-2015-386.

11. Li, G., Rao, M., Ouyang, C., Zhang, S., Peng, Z., & Jiang, T. (2015). Distribution characteristics of phosphorus in the metallic iron during solid-state reductive roasting of oolitic hematite ore. ISIJ International, 55(11), 2304-2309. https://doi.org/10.2355/isijinternational.ISIJINT-2015-212.

 

Visitors

6226991
Today
This Month
All days
823
53668
6226991

Guest Book

If you have questions, comments or suggestions, you can write them in our "Guest Book"

Registration data

ISSN (print) 2071-2227,
ISSN (online) 2223-2362.
Journal was registered by Ministry of Justice of Ukraine.
Registration number КВ No.17742-6592PR dated April 27, 2011.

Contacts

D.Yavornytskyi ave.,19, pavilion 3, room 24-а, Dnipro, 49005
Tel.: +38 (056) 746 32 79.
e-mail: This email address is being protected from spambots. You need JavaScript enabled to view it.
You are here: Home About the journal EngCat Archive 2021 Content №4 2021 Recovery of iron and phosphorus removal from Gara Djebilet iron ore (Algeria)